The aim of this study was the recovery of copper from the oxide copper ore by froth flotation and agitating sulphuric acid (H 2 SO 4) ... ground particles under microscope. During the flotation tests; the effects of type and dosage of collectors, pH, and dosage of activator Na ... and pulp density on extraction of copper were examined. Agitating

Get Price

Jun 15, 2018 Generally, the flotation tailings are produced as a byproduct during the beneficiation of copper ore, namely froth flotation before the pyrometallurgical processes. According to the literature data, about 90–95% of the plant general tailings, i.e. flotation tailings and cleaning tailings, are produced from flotation process and represented as

Get Price

The ores typically contain low percentages of copper and have to be concentrated by, for example, froth flotation before refining. Note: You will find a brief description of froth flotation on the introduction to metal extraction page

Get Price

Sulphide ores are the major sources of base metals like Copper, Lead, Zinc, Nickel and Cobalt. Beneficiation of. these base metal sulphide minerals is predominantl y through the froth flotation

Get Price

Copper is extracted from its principal ore copper pyrites (CuFeS 2). The ore is concentrated by froth flotation process. The concentrated ore is roasted in a reverberatory furnace when the following reactions occur. 1. The volatiles like sulphur and arsenic escape as gases S + O 2----- SO 2 4AS + 3O 2----- 2AS 2 O 3 2

Get Price

Jan 16, 2018 Fig. 1 shows the rougher flotation in a certain copper flotation site. During the whole flotation process, rougher is the first step of screening after ore is ground, mixed with water and classified. The products from rougher include the rougher froth on top of the cell and the pulp flow at the bottom of the cell

Get Price

Copper processing is a complicated process that begins with mining of the ore (less than 1% copper) and ends with sheets of 99.99% pure copper called cathodes, which will ultimately be made into products for everyday use.The most common types of ore, copper oxide and copper sulfide, undergo two different processes, hydrometallurgy and pyrometallurgy, respectively, due to the different

Get Price

froth layer. Particles that are retained in the froth are recovered at the lip of the froth weir at the edge of the flotation cell. The recovery of the froth is accomplished by the natural mobility of the froth which causes it to flow over the weir and the recovery is sometimes assisted by mechanical paddles

Get Price

Oct 17, 2016 A total recovery of more than 97% of the gold and silver is made by flotation, while the combined flotation-cyanidation process gives an overall extraction of 95%. The installation is much more compact and its capital cost far less than one embodying fine grinding and cyaniding of the whole tonnage, and it can be run with lower operating

Get Price

Copper oxide ores have occasionally been treated via froth flotation via sulfidation of the oxide minerals with certain chemicals which react with the oxide mineral particles to produce a thin rime of sulfide (usually chalcocite), which can then be activated by the froth flotation plant

Get Price

Oct 05, 2013 COPPER This page looks at the extraction of copper from its ... froth flotation before refining. Note: You will find a brief description of froth flotation on the introduction to metal ... of the new solution. Copper(II) ions are deposited as copper on the cathode (for the electrode equation, see under the purification of copper below)

Get Price

The reaction sequence with xanthate is Chalcocite copper blue speckle copper pyrite. 2. Secondary copper ore and oxidation influence. 3. Influence of ded particles , the more fine of the particles the much difficult to make the flotation. 4

Get Price

Dec 20, 2018 Gold flotation. The Froth Flotation Method is means separating minerals according to their different physical and chemical properties. According to classification, the flotability of gold and silver minerals is included in the first category of natural and non-ferrous heavy metal sulfides, characterized by low surface wettability and easy flotation, which can be flotation by xanthate collectors

Get Price

At those years in the past, at one of the Soviet plants, 1% copper containing oxide copper ore was floated with a recovery of 80% and a copper grade of 19%. Wills (2006) mentioned that oxide cap of primary copper deposits can be mined selectively and successfully processed by froth flotation

Get Price

Mar 10, 2016 Flowsheet of Copper Extraction Process by Froth Flotation. Post navigation. Previous. Next. by L D Michaud March 19, 2017 March 10, 2016 Categories Flotation, Flowsheets & Flowcharts Tags Copper Flotation, Copper Froth Flotation, Small Process Equipment Post navigation. Previous

Get Price

Jun 15, 2018 The copper concentrate was first prepared by flotation under the optimal conditions obtained from the previous study, which was pH 10, pulp densities 25%, collector (PAX) dosage 100 g/t‒ore, sulfurizing reagent (NaHS) dosage 1000 g/t, frother (MIBC) dosage 200 g/t‒ore, and flotation time 15 min . The copper grade was upgraded to 0.65 mass% from the initial 0.34 mass% under the

Get Price